RTV-1 Silicone Rubber
RTV-1 silicone is a condensed silicone rubber that is gradually cured from outside to inside by contacting with moisture in the air. RTV-1 silicone rubber купитьare used in bonding, sealing, encapsulating photovoltaic module components including photovoltaic frame, junction box and micro-inverter, power industry including circuit boards, electronic components, light emitting diode industry including lamp beads, lamp cap and light bar, home appliance including air conditioner, fridge, washing machine, and microwave oven, induction cooker, new energy vehicle including electronic component. GOLOHO RTV1silicone rubbers are designed to provide long-term bonding, sealing, encapsulating and protection against moisture, environmental degradation, mechanical and thermal shock, heat dissipation and vibration where a room-temperature-curing product is preferred.
When using RTV-1 silicone rubber, all surfaces must be clean and dry. Degrease and wash off any contaminants that could impair adhesion. Suitable solvents include isopropyl alcohol, acetone, or methyl ethyl ketone. Apply a bead of RTV-1 silicone rubber to one of the prepared surfaces, then quickly cover with the other substrate to be bonded. On exposure to moisture, the freshly applied material will “skin over” in about 10 to 15 minutes at room temperature and 50% relative humidity. Any tooling should be completed before this skin forms. The surface is easily tooled with spatula. GOLOHO RTV-1 silicone rubbers will be tack free in about 5 to 60 minutes. After skin formation, cure continues inward from the surface. In 24 hours (at room temperature and 50% relative humidity), GOLOHO RTV-1 silicone rubbers will cure to a depth of 2 to 3 mm. Very deep sections, especially when access to atmospheric moisture is restricted, will take longer to cure completely. Cure time is also extended at lower humidity levels. Before handing and packaging bonded components, users are advised to wait a sufficiently long time to ensure that the integrity of the adhesive seal is not affected. This will depend on many factors and should be determined by user for each specific application.
GOLOHO POLYMER was founded in China, setting up factory to develop and produce rtv grease.Now the company embraces united and dynamic team, experienced R&D center, advanced detection method, strong manufacture capacity as well as customer-oriented service.If you want to buy silicone rtv, just contact us!
在线联系供应商
Other supplier products
 |
Thermally Conductive Silicone Adhesive - 2752 | Are you looking for RTV silicone thermal conductivity? FEATURES OF GOLOHO-2752 GOLOHO-2741 is a high performance thermally conductive RTV silicone ... |
 |
RTV-1 Silicone Rubber | RTV-1 silicone is a condensed silicone rubber that is gradually cured from outside to inside by contacting with moisture in the air. It can be also... |
 |
Two-Part, 1 To 1 Mix Ratio Transparent Silicone Gel - 324C-AB | SPECIAL FEATURES OF GOLOHO-324C-AB 1:1 Two-part, 1:1 mix ratio Low viscosity Room temperature accelerated cure, no small molecule release Suitable ... |
 |
Heat Resistant Silicone Adhesive/Sealant - 3912R | FEATURES OF GOLOHO-3912R ·UL certificated product(E254532) ·One-part RTV silicone rubber ·Exposure to humid air can be cured a... |
 |
Addition Silicone Rubber | GOLOHO heat cured silicone rubberproduces no by-products in the curing process, allowing their use in deep section and complete confinement. GOLOHO... |
Same products
 |
LFR30B Infrared Forehead Thermometer | 卖方: Lepu Medical Technology(Beijing)Co.,Ltd | Blue dots focusing calibration system help users to find the optimal measuring distance LFR30B... |
 |
Hot Shrinkage Mould | 卖方: Guangdong Yufeng Industries Co.,Ltd | The life of hot shrinkage mouldis closely related to the extruded material and extrusion ratio, a... |
 |
Copper Tape With Conductive Adhesive | 卖方: HOPELIGHT ELECTRICAL CO.,LIMITED | Copper Tape With Conductive Adhesive Copper tape with conductive adhesive is made of high-qualit... |
 |
Copper Tape | 卖方: HOPELIGHT ELECTRICAL CO.,LIMITED | Copper tape, also called copper foil shielding tape, is made of copper with a purity higher than ... |
 |
Black Polyester Tape | 卖方: HOPELIGHT ELECTRICAL CO.,LIMITED | wholesale polyester tape Black polyester tapealso called as a black shading tape, Black polyes... |
