EM-5 Flue Gas Analyzer
Overview
EM-5 series flue gas analyzer is a series of self-developed gas analysis products for online gas analysisof domestic as well as foreign environmental protection and industrial control. Based on UV Differential Optical Absorption Spectroscopy (DOAS) technology and chemometrics algorithm (PLS), it is able to measure the gas concentration of SO2, NO, NO2, O2, NH3, Cl2, O3, H2S, Ch3 and etc. With features of high measurement accuracy, high reliability, fast response time, wide application scope, it can be widely applied in occasions of environment online monitoring, industrial process control, safety monitoring and etc.
Depended on years of flue gas analyzer research experience and combined with practical experience of thousands of successful application cases, the analyzer has derived multiple types (standard type, low emission type, ultra-low emission type, and customized type) to meet different index requirements in different working condition.
UV DOAS technology. The optical technology platform consists of a light source, gas chamber, optical fiber and spectrograph (including the diaphragm, a holographic grating, linear array detector) and other optical components.
Ultraviolet light emitted by light source enters the gas chamber by an optical window and absorbed by measured sample gas flowed through the gas chamber. The light carrying sample absorption information will be gathered by the lens and coupled into an optical fiber and then transmits into spectrometer through fiber. After light splitting and photo-voltaic conversion, the gas absorption spectrum is obtained.
The corresponding component concentration in the gas can be calculated by analyzing the spectrum.
Note: the difference among standard analyzer, low emission analyzer, and ultra-low analyzer is the different optical path length of gas chamber: for standard analyzer, it adopts dual lens collimation system with 0.25m optical path; for low emission analyzer, it adopts multiple return structure with 1m optical path; for ultra-low emission analyzer, it uses white cell structure.
Features Of EM-5 online gas analyzer
High measurement accuracy
Minimum detection limit of SO2, NO, NO2 can reach 1mg/m3 (15m optical path)
Ultraviolet has no moisture absorption, undisturbed by moisture and dust
No cross interference between measured gases ( refer to table 1)
Measure NO and NO2 simultaneously without converter
Low detection limit
|
Measuring gas Interference |
SO2 |
NO |
NO2 |
O2 |
|
SO2 (500ppm) |
/ |
<1ppm |
no |
no |
|
NO (500ppm) |
no |
/ |
no |
no |
|
NO2 (500ppm) |
no |
<1ppm |
/ |
no |
|
H2O (no dew) |
no |
no |
no |
no |
|
CO (1000ppm) |
no |
no |
no |
no |
|
CO2 (20%) |
no |
no |
no |
no |
|
O2 (21%) |
no |
no |
no |
/ |
High reliability
Small zero drift and span drift
Modular design
No optical moving parts, without vibration influence
Strong gas chamber, low cost
Automatic adjustment spectrum technology, long maintenance-free period
Adopt pulse light source with 10-year service life
Technical Parameter Of EM-5 Flue Gas Analyzer
|
Measurement Principle |
UV-DOAS＋PLS |
|||||||
|
Versions |
Regular range |
Low range |
Ultra-low range |
|||||
|
Ranges |
My range |
Max range |
My range |
Max range |
My range |
Max range |
||
|
Component |
SO2 |
0-300ppm |
0-3000ppm |
0-100ppm |
0-300ppm |
0-50ppm |
0-100ppm |
|
|
NO |
0-300ppm |
0-3000ppm |
0-100ppm |
0-300ppm |
0-50ppm |
0-100ppm |
||
|
NO2 |
0-500ppm |
0-4000pp |
0-300ppm |
0-1000ppm |
0-100ppm |
0-200ppm |
||
|
O2 (ECD or ZrO2) |
0-5% |
0-25% |
0-5% |
0-25% |
0-5% |
0-25% |
||
|
Linearity |
≤±3%F.S. |
|||||||
|
Repeatability |
≤2% |
|||||||
|
Zero Drift |
≤ ± 2% FS / 7d |
|||||||
|
Span Drift |
≤ ± 2% FS / 7d |
|||||||
|
Response Time(T90) |
≤50s |
|||||||
|
Working Temperature |
-20 ℃ ～ ＋ 50 ℃ |
|||||||
|
Preheating Time |
No preheating |
20min |
40min |
|||||
|
Sample Gas Interface |
Φ6 Bi-Lok |
|||||||
|
Sample Gas Flow |
Range: (0.5 ～ 2) L / min, fluctuation ＜ 25% |
|||||||
|
Sample Gas Pressure |
Current ambient pressure ±0.1Bar |
|||||||
|
SampleGas Temp. |
0 ℃ ～ ＋ 50 ℃ |
|||||||
|
Sample Gas Humidity |
No condensation (under sample gas temperature) |
|||||||
|
4-20mA Input |
3 , configurable, 100Ω load |
|||||||
|
4-20mA Output |
5, output content can be configured, maximum load capacity ≤800Ω |
|||||||
|
Switching valueInput |
6 , configurable |
|||||||
|
Relay Output |
14, output content can be configured. DC30V2A |
|||||||
|
Digital I / O |
1×Rs232, 1×Rs485 (Support Modbus protocol) |
|||||||
|
Installation Method |
19’panel |
|||||||
|
Supply Voltage |
220VAC ± 10% |
|||||||
|
Rated Power |
About 100W |
About 120W |
||||||
Application Of EM-5 Flue Gas Analyzer
Coal-fired power plantCement plantIndustrial furnaceDeSOX process monitoringDeNOX process monitoringWaste incineration plantPVC process in chlor-alkali plantTitanium dioxide production processSulfur recovery processNatural gas purification processMethyl iodide analysis for the coal chemical industryOn-line air monitoring
Hangzhou Zetian Technology is committed to the integrity, strength and quality of our air quality monitor. We're internationally recognized.We have 5 gas analyzer for sale! To learn more about the flue gas analyser working principle, please contact us!
Send product request
Other supplier products
 |
ERMS-2000-V Vertical Stationary Vehicle Exhaust Remote Sensing System | Overview ERMS2000-V vertical stationary vehicle exhaust remote sensing system is a system that sets above the multi-lane and monitors the exhaust p... |
 |
EM-5P Portable Flue Gas Analyzer | Overview EM-5P portable gas monitoring system mainly consists of gas monitoring sensors (SO2, NOx, CO, CO2), sample conditioning unit, sampling uni... |
 |
EM-5P Portable Flue Gas Analyzer | Overview EM-5P portable gas monitoring system mainly consists of gas monitoring sensors (SO2, NOx, CO, CO2), sample conditioning unit, sampling uni... |
 |
EM-5 Online Flue Gas Analyzer | Overview Of EM-5 Continuous Flue Gas Analyzer EM-5 series continuous online flue gas analyzeris a series of self-developed gas analysis products fo... |
 |
WDet-5000UVI Immersion UV Water Analyzer | Overview WDet-5000UVI is the first full-spectrum (200-800nm) immersion UV water analyzerat home. With features of the delicate and convenient struc... |
Same products
 |
Flexo Printing Machine | Seller: RUIAN LOYAL MACHINERY CO.,LTD | In the 1980s, flexographic printing technology developed rapidly. The performance of flexographic... |
 |
Lejia LJ-Spray Printing Embroidery Series | Seller: Zhejiang Lejia Electrical Machinery Co., Ltd. | LJ-Spray Printing embroidery machine Series Rely on technology research and development, Lejia co... |
 |
LJ-928 Sequin High speed computerized embroidery machine | Seller: Zhejiang Lejia Electrical Machinery Co., Ltd. | Sequin/Beads Embroidery Machine Series uses lock stitches embroidery without any falling off of... |
 |
Lejia LJ-1204 4 heads Cap embroidery machine | Seller: Zhejiang Lejia Electrical Machinery Co., Ltd. | LJ- Cap/T-shirt/Tubular series of embroidery machine adopts overhanging type hook base, integrate... |
 |
LJ-Cap/T-shirt/ Tubular Series | Seller: Zhejiang Lejia Electrical Machinery Co., Ltd. | LJ- Cap/T-shirt/Tubular series of embroidery machine adopts overhanging type hook base, integra... |
